1. Welcome,
    SXSNation is a UTV Community that brings enthusiasts together regardless of brand, a place to find local rides, partake in discussion, buy or sell within a marketplace, or just rant about anything side by sides. Interact directly with top Vendors in the Industry, find exclusive discounts and specials and participate in weekly giveaways! If you haven't registered yet, what are you waiting for?
    Dismiss Notice

Need help

Discussion in 'RZR Nation' started by Firefighter62, Mar 30, 2020.

Users Viewing Thread (Users: 0, Guests: 0)

  1. Firefighter62

    Firefighter62 Ken SXS Nation Rookie

    Joined:
    Mar 30, 2020
    Posts:
    1
    Likes Received:
    0
    Location:
    Patton pa
    Side X Side(s):

    2013 Polaris rzr 900xp

    Have a 2013 Polaris rzr 900xp Ran good blew passenger side break line replaced it and now when u push the break to start it it won’t turn over have power and the fuel pump turns on but the motor won’t start !!
     
  2. Seastacker

    Seastacker Carl Moderator

    Joined:
    Feb 1, 2016
    Posts:
    2,782
    Likes Received:
    1,833
    Location:
    SE Michigan
    Side X Side(s):

    2019 Polaris General 4

    I suspect you still have air in the brake lines. Polaris uses a pressure switch in the brake master cylinder as a safety. With air in the lines (which compresses), it's probably not enough to trigger this switch. I cant recall if the switch is normally open or closed, but to test it find the connector on the brake master cyl. Unplug it and try turning over. If no go, take a small wire jumper and connect the 2 pins in the connector and try it again. It will probably turn over now.

    There is also a possibility the switch went bad, but that is unlikely considering it was working fine prior to your brake line issue.

    If the jumper wire works, I would suggest bleeding the entire system out. Always start with the furthest caliper away from the master cyl, working your way to the closest. It takes 2 people and some patience (or a brake bleeder).
     
    Sponge60 and rocksalot like this.
  3. Rockin Ronnie

    Rockin Ronnie Ron Moderator

    Joined:
    May 20, 2017
    Posts:
    842
    Likes Received:
    508
    Location:
    Evart, Michigan
    Side X Side(s):

    17 Polaris General
    13 Polaris Ranger

    What he said ^^^^^^^ :cool: :rolleyes: :D
     
  4. Sponge60

    Sponge60 Glenn SXS Nation Regular

    Joined:
    Oct 2, 2017
    Posts:
    35
    Likes Received:
    27
    Location:
    Outer Banks, NC
    Side X Side(s):

    2017 RZR 900 Trail

    Did that fix the issue?
     

Share This Page